|
|
 |
|
 | Pah-NolTM
Non-Toxic -60º Antifreeze
Material Safety Data Sheet (MSDS)
|
Section 1: Identification
Section 2: Hazardous Ingredients
Section 3: Physical Data
Section 4: Fire and Explosion Hazard Data
Section 5: Reactivity Data
Section 6: Health Hazard Data
Section 7: Spill or Leak Procedures
Section 8: Special Protective Information
Section 9: Special Precautions
Section 1: Identification
| MANUFACTURER: | Houghton Chemical Corporation |
| ADDRESS: | 52 Cambridge Street, Allston, MA 02134 |
| EMERGENCY TELEPHONE: | (617) 254-1010
1-800-777-2466
or
Chemtrec 1-800-424-9300 |
| CHEMICAL NAME & SYNONYMS: | Non-Toxic Antifreeze |
| CHEMICAL FAMILY: | Propylene Glycol Based |
| FORMULA: | Trade Secret |
| CAS REGISTRY NUMBER: | Not applicable for blended product |
| DOT SHIPPING CLASSIFICATION: | Not Regulated |
| PRODUCT NUMBER: | 61738, 62738, 63738, 65738 |
Section 2:
Hazardous Ingredients
| MATERIAL | CAS # | % | TLV (Units) |
| Propylene Glycol | 57-55-6 | 34 | Not applicable |
| Water | 7732-18-5 | 65 | Not applicable |
| Corrosion Inhibitors | TSR#801 00075-5002P | 1 | Not applicable |
Section 3:
Physical Data
| BOILING POINT: | 217ºF |
| FREEZING POINT: | 5º F |
| SPECIFIC GRAVITY: | |
| VAPOR PRESSURE AT 20ºC: | 0.1 mm Hg. |
| VAPOR DENSITY (air = 1): | 2.1 |
| SOLUBILITY IN WATER: | Complete |
| % VOLATILE BY VOLUME: | Greater than 95% |
| EVAPORATION RATE (H2O = 1): | Less than 1 |
| APPEARANCE AND ODOR: | Distinct Orange, odorless |
Section 4:
Fire & Explosion Hazard Data
| FLASH POINT: | None |
| AUTO IGNITION TEMPERATURE: | None |
| FLAMMABLE LIMITS IN AIR: | Not applicable |
| EXTINGUISHING MEDIA: | Not applicable |
| SPECIAL FIRE FIGHTING
PROCEDURES: | Not applicable |
| UNUSUAL FIRE AND EXPLOSION
HAZARDS: | None |
Section 5:
Reactivity Data
| STABILITY: | This material is stable. |
| INCOMPATIBILITY: | Keep away from strong oxidizing agents. |
| HAZARDOUS DECOMPOSITION
PRODUCTS: | Not applicable. |
| HAZARDOUS POLYMERIZATION: | Will not occur. |
Section 6:
Health Hazard Data
| THRESHOLD LIMIT VALUE: | Nuisance Dust 15 mg/M³ 8 Hours. |
| EFFECTS OF OVEREXPOSURE: | Slight irritation to eyes and skin. |
| EYE CONTACT: | Irritation may result. |
| SKIN: | No significant signs or symptoms expected. |
| INHALATION: | This material is not expected to be a respiratory hazard except if aspirated. If swallowed, can enter lungs and cause damage. |
| INGESTION: | No significant signs or symptoms are expected. |
Emergency & First Aid Procedures:
| EYES: | Flush with water for at least 15 minutes. |
| SKIN: | Flush with water, wash with mild soap if available. |
| INHALATION: | Remove to fresh air. |
| INGESTION: | Do not induce vomiting. Aspiration may cause lung damage. |
Section 7:
Spill or Leak Procedures
| STEPS TO BE TAKEN IN CASE MATERIAL IS SPILLED OR RELEASED: |
This liquid is biodegradable but large spills may contaminate public waters. Prevent flow to sewers/public waters. Restrict clean up water use. Notify water supply environment authorities. Impound/recover large land spills. Soak up small spills with absorbent material. Use suitable disposal containers. High biodegradability can stimulate algae growth. Dispose residue to reduce possible aquatic harm. |
| WASTE DISPOSAL METHOD: | Consult with local sewer, municipal, state and/or federal agencies to determine appropriate current disposal options. |
Section 8:
Special Protective Information
| RESPIRATORY PROTECTION: | Normally not required. |
| VENTILATION: | None needed under anticipated conditions of normal use beyond that needed for normal comfort control. |
| PROTECTIVE GLOVES: | If contact with hot liquid possible use suitable protective gloves. |
| EYE PROTECTION: | If contact with hot liquid possible use suitable splash goggles and face shield. |
| OTHER PROTECTIVE EQUIPMENT: | Not applicable |
Section 9:
Special Precautions
| PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: |
Follow good work/hygiene practices. Provide safety shower and wash in immediate area. Workers should wash with soap and water before eating, smoking or using toilet facilities. Launder contaminated clothing before re-use. |
|
